Removal of cephalexin using green montmorillonite loaded with TiO2 nanoparticles in the presence potassium permanganate from aqueous solution

authors:

avatar athar entezai , avatar Mehdi Fazlzadeh , avatar ali ahmadfazeli , avatar ali shayeghi , avatar rasoul khosravi , *

Koomesh: Vol.18, issue 3; 388-396
published online: December 28, 2016
article type: issue_documents_importer
received: October 03, 2016
accepted: November 02, 2016

how to cite: entezai A, Fazlzadeh M, ahmadfazeli A, shayeghi A, khosravi R. Removal of cephalexin using green montmorillonite loaded with TiO2 nanoparticles in the presence potassium permanganate from aqueous solution. koomesh. 2016;18(3):e151129. 

Abstract

Introduction: Because of the disadvantages of antibiotics in the ecosystem, it must remove before discharging wastewater containing them into the environment by an effective process. The aim of this study was cephalexin removal by local green montmorillonite loaded with TiO2 nanoparticles (TiO2/GLM) in the presence of potassium permanganate. Materials and Methods: This experimental study was performed in batch. In this study, green montmorillonite found in the area of Ardabil sarcham used as base absorbent and to improve the efficiency of cephalexin removal stabilized TiO2 nanoparticles on it using potassium permanganate. Then, the most important variables affecting the process have been investigated. Scanning electron microscope (SEM) and Fourier transform infrared spectroscopy (FTIR) tests used to investigate absorbent surface morphology and functional groups on the adsorbent respectively. The samples were analyzed by a spectrophotometer and data analysis was performed using Excel software. Results: SEM images showed that the absorbent surface has a high roughness and FTIR test showed change the functional groups because loading of TiO2 nanoparticles.the optimal condition was pH = 5, detention time= 60 min and adsorbent dose = 4 g/l for initial Cephalexin concentration of 25 mg/l. Also the results showed by decreasing temperature, removal efficiency was increased. Conclusion:  Due to the high efficiency of TiO2/GLM in the absorption of cephalexin as well as its morphology did not change after adsorption process, we can say that this adsorbent can be used as a cheap and efficient absorbent for the removal of cephalexin used

References

  • 1.

    Ajoudanian N, Nezamzadeh-Ejhieh A. Enhanced photocatalytic activity of nickel oxide supported on clinoptilolite nanoparticles for the photodegradation of aqueous cephalexin. Mate Sci Semiconductor Proc 2015; 36: 162-169.

  • 2.

    Liu H, Liu W, Zhang J, Zhang C, Ren L, Li Y. Removal of cephalexin from aqueous solutions by original and Cu(II)/Fe(III) impregnated activated carbons developed from lotus stalks Kinetics and equilibrium studies. J Hazard Mater 2011; 185: 1528-1535.

  • 3.

    Samarghandi MR, Al-Musawi TJ, Mohseni-Bandpi A, Zarrabi M. Adsorption of cephalexin from aqueous solution using natural zeolite and zeolite coated with manganese oxide nanoparticles. J Molecul Liquids 2015; 211: 431-441.

  • 4.

    Legnoverde MS, Simonetti S, Basaldella EI. Influence of pH on cephalexin adsorption onto SBA-15 mesoporous silica: Theoretical and experimental study. Appl Surface Sci 2014; 300: 37-42.

  • 5.

    Aksu Z, Tun . Application of biosorption for penicillin G removal: comparisonwith activated carbon. Proc Biochem 2005; 40: 831-847.

  • 6.

    Ahmed MJ, Theydan SK. Adsorption of cephalexin onto activated carbons from Albizia lebbeck seed pods by microwave-induced KOH and K2CO3 activations. Chem Eng J 2012; 211-212: 200-207.

  • 7.

    Ahmed MB, Zhou JL, Ngo HH, Guo W. Adsorptive removal of antibiotics from water and wastewater: Progress and challenges. Sci Total Environ 2015; 532: 112-126.

  • 8.

    Ncibi MC, Sillanpaa M. Optimized removal of antibiotic drugs from aqueous solutions using single, double and multi-walled carbon nanotubes. J Hazard Mater 2015; 298: 102-110.

  • 9.

    Pirsaheb M, Dargahi A, Hazrati S, Fazlzadehdavil M. Removal of diazinon and 2, 4-dichlorophenoxyacetic acid (2, 4-D) from aqueous solutions by granular-activated carbon. Desalination and Water Treatment 2014; 52: 4350-4355.

  • 10.

    Uslu H, Datta D, Azizian S. Separation of chromium (VI) from its liquid solution using new montmorillonite supported with amine based solvent. J Mol Liquids 2016; 215: 449-453.

  • 11.

    Wang G, Hua Y, Su X, Komarneni S, Ma S, Wang Y. Cr(VI) adsorption by montmorillonite nanocomposites. Appl Clay Sci 2016; 124-125: 111-118.

  • 12.

    Kadoura A, Narayanan Nair AK, Sun S. Adsorption of carbon dioxide, methane, and their mixture by montmorillonite in the presence of water. Microporous and Mesoporous Materials 2016; 225: 331-341.

  • 13.

    Lyu B, Gao J, Ma J, Gao D, Wang H, Han X. Nanocomposite based on erucic acid modified montmorillonite/sulfited rapeseedoil: Preparation and application in leather. Appl Clay Sci 2016; 121-122: 36-45.

  • 14.

    Olad A, Nosrati R, Najjari H, Nofouzi K. Preparation and investigation of hydrophilic, photocatalytic, and antibacterial polyacrylic latex coating containing nanostructured TiO2/Ag+-exchanged-montmorillonite composite material. Appl Clay Sci 2016; 123: 156-165.

  • 15.

    Badran MM, Harisa GI, AlQahtani SA, Alanazi FK, Zoheir KM. Pravastatin-loaded chitosan nanoparticles: Formulation, characterization and cytotoxicity studies. J Drug Delivery Sci Technol 2016; 32: 1-9.

  • 16.

    Ghaedi M, Rahimi MR, Ghaedi AM, Tyagi I, Agarwal S, Gupta VK. Application of least squares support vector regression and linear multiple regression for modeling removal of methylorange onto tin oxide nanoparticles loaded on activated carbon and activated carbon prepared from Pistacia atlantica wood. J Colloid Interface Sci 2016; 461: 425-434.

  • 17.

    Jiang HM, Yan ZP, Zhao Y, Hu X, Lian HZ. Zincon-immobilized silica-coated magnetic Fe3O4 nanoparticles for solid-phase extraction and determination of trace lead in natural and drinking waters by graphite furnace atomic absorption spectrometry. Talanta 2012; 94: 251-256.

  • 18.

    Lu D, Fang P, Liu X, Zhai S, Li C, Zhao X, et al. A facile one-pot synthesis of TiO2-based nanosheets loaded with MnxOy nanoparticles with enhanced visible lightdriven photocatalytic performance for removal of Cr (VI) or RhB. Appl Catalysis B: Environmental 2015; 179: 558-573.

  • 19.

    Nishikawa M, Fukuda M, Nakabayashi Y, Saito N, Ogawa N, Nakajima T, et al. A method to give chemically stabilities of photoelectrodes for water splitting: Compositing of a highly crystalized TiO2 layer on a chemically unstable Cu2O photocathode using laser-induced crystallization process. Appl Surface Sci 2016; 363: 173-180.

  • 20.

    Sun B, Zhou G, Gao T, Zhang H, Yu H. NiO nanosheet/TiO2 nanorod-constructed pn heterostructures for improved photocatalytic activity. Appl Surface Sci 2016; 364: 322-331.

  • 21.

    Parastar S, Nasseri S, Borji SH, Fazlzadeh M, Mahvi AH, Javadi AH, et al. Application of Ag-doped TiO2 nanoparticle prepared by photodeposition method for nitrate photocatalytic removal from aqueous solutions. Desalination and Water Treatment 2013; 51: 7137-7144.

  • 22.

    Shi Q, Zhang J, Zhang C, Nie W, Zhang B, Zhang H. Adsorption of Basic Violet 14 in aqueous solutions using KMnO4-modified activated carbon. J Colloid Interface Sci 2010; 343: 188-193.

  • 23.

    Chen LP, Gao YH, Liu XL. Influences of KMnO4on the syntheses and properties of CaWO4 thin films prepared by galvanic cell methods. Mater Chem Phys 2014; 146: 363-368.

  • 24.

    Zhang Y, Wang Y, Zhou L. Influence of excess KMnO4 on the adsorption of powdered activated carbon. Chem Eng J 2013; 226: 279-285.

  • 25.

    Hashem FS. Adsorption of Methylene Blue from Aqueous Solutions using Fe3O4/Bentonite Nanocomposite. Hydrol Current Res 2012; 3(5): 2-6.

  • 26.

    Khosravi R, Fazlzadeh M, Samadi Z, Mostafavi H, Taghizadeh A, Dorri H. Investigation of Phenol Adsorption from Aqueous Solution by Carbonized Service Bark and Modified-Carbonized Service Bark by ZnO. J Health 2013; 4: 21-30. (Persian).

  • 27.

    Ncibi MC, Sillanp M. Optimized removal of antibiotic drugs from aqueous solutions using single, double and multi-walled carbon nanotubes. J Hazard Mater 2015; 298: 102-110.

  • 28.

    Pouretedal H, Sadegh N. Effective removal of amoxicillin, cephalexin, tetracycline and penicillin G from aqueous solutions using activated carbon nanoparticles prepared from vine wood. J Water Proc Engin 2014; 1: 64-73.

  • 29.

    Mena-Duran C, Kou MS, Lopez T, Azamar-Barrios J, Aguilar D, Dominguez M, et al. Nitrate removal using natural clays modified by acid thermoactivation. Appl Surf Sci 2007; 253: 5762-5766.

  • 30.

    Pouretedal HR, Sadegh N. Effective removal of Amoxicillin, Cephalexin, Tetracycline and Penicillin G from aqueous solutions using activated carbon nanoparticles prepared from vine wood. J Water Proc Engin 2014; 1: 64-73.

  • 31.

    Nezamzadeh-Ejhieh A, Tavakoli-Ghinani S. Effect of a nano-sized natural clinoptilolite modified by the hexadecyltrimethyl ammonium surfactant on cephalexin drug delivery. Comptes Rendus Chimie 2014; 17: 49-61. (Persian).

  • 32.

    Khosravi R, Fazlzadehdavil M, Barikbin B, Taghizadeh AA. Removal of hexavalent chromium from aqueous solution by granular and powdered Peganum Harmala. Appl Surface Sci 2014; 292: 670-677.

  • 33.

    Rahmani AR, Shabanloo A, Fazlzadeh M, Poureshgh Y. Investigationof operational parameters influencing in treatment of dye from water by electro-Fenton process. Desalination and Water Treatment 2016; 1-8.

  • 34.

    Abdoallahzadeh H, Alizadeh B, Khosravi R, Fazlzadeh M. Efficiency of EDTA modified nanoclay in removal of humicAcid from aquatic solutions. J Mazandaran Univ Med Sci 2016; 26: 111-125.

  • 35.

    Albadarin AB, Mangwandi C, Al-Muhtaseb AaH, Walker GM, Allen SJ, Ahmad MN. Kinetic and thermodynamics of chromium ions adsorption onto low-cost dolomite adsorbent. Chem Engin J 2012; 179: 193-202.

  • 36.

    Zhang J. Phenol removal from water with potassium permanganate modified granular activated carbon. J Environment Protect 2013; 041: 411-417.

  • 37.

    Moussavi G, Alahabadi A, Yaghmaeian K, Eskandari M. Preparation, characterization and adsorption potential of the NH4Cl-induced activated carbon for the removal of amoxicillin antibiotic from water. Chem Engin J 2013; 217: 119-128.

  • 38.

    Zarrabi M, Noori Sepehr M, Amrollahi M, Taghavi M. Biosorption of fluoride by apple pulp from aqueous solution. Koomesh 2015; 16: 213-219. (Persian).

  • 39.

    Ghaneian MT, Jamshidi B, Amrollahi M, Dehvari M, Taghavi M. Application of biosorption process by pomegranate seed powder in the removal of hexavalent chromium fromaqueous environment. Koomesh 2014; 15: 206-211. (Persian).##.